Английская Википедия:Dibutyl phthalate
Шаблон:Use dmy dates Шаблон:Chembox
Dibutyl phthalate (DBP) is an organic compound which is commonly used as a plasticizer because of its low toxicity and wide liquid range. With the chemical formula C6H4(CO2C4H9)2, it is a colorless oil, although impurities often render commercial samples yellow.[1]
Production and use
DBP is produced by the reaction of n-butanol with phthalic anhydride.[1] DBP is an important plasticizer that enhances the utility of some major engineering plastics, such as PVC. Such modified PVC is widely used in plumbing for carrying sewerage and other corrosive materials.[1]
Degradation
Hydrolysis of DBP leads to phthalic acid and 1-butanol.[2] Monobutyl phthalate (MBP) is its major metabolite.[3]
Biodegradation
Biodegradation by microorganisms represents one route for remediation of DBP. For example, Enterobacter species can biodegrade municipal solid waste—where the DBP concentration can be observed at 1500 ppm—with a half-life of 2–3 hours. In contrast, the same species can break down 100% of dimethyl phthalate after a span of six days.[4] The white rot fungus Polyporus brumalis degrades DBP.[5] DBP is leached from landfills.[6]
Physical properties relevant to biodegradation
As reflected by its octanol-water partition coefficient of around 4, it is lipophilic, which means that it is not readily mobilized (dissolved by) water. Nonetheless, dissolved organic compounds (DOC) increase its mobility in landfills.[7][8]
DBP has a low vapor pressure of 2.67 x 10−3 Pa. Thus DBP does not evaporate readily (hence its utility as a plasticizer).[9] The Henry's Law constant is 8.83 x 10−7 atm-m3/mol.[2]
Legislation
DBP is regarded as an endocrine disruptor.[10]
European Union
The use of this substance in cosmetics, including nail polishes, is banned in the European Union under Directive 76/768/EEC 1976.[11]
The use of DBP has been restricted in the European Union for use in children's toys since 1999.[12]
An EU Risk Assessment has been conducted on DBP and the outcome has now been published in the EU Official Journal. To eliminate a potential risk to plants in the vicinity of processing sites and workers through inhalation, measures are to be taken within the framework of the IPPC Directive (96/61/EC) and the Occupational Exposure Directive (98/24/EC)[13] Also includes the 2004 addendum.
Based on urine samples from people of different ages, the European Commission Scientific Committee on Health and Environmental Risks (SCHER) concluded that total exposures to DBP should be further reduced.[14]
Under European Union Directive 2011/65/EU [15] revision 2015/863,[16] DBP is limited to max 1000 ppm concentration in any homogenous material.
United States
Dibutyl phthalate (DBP) is one of the six phthalic acid esters found on the Priority Pollutant List, which consists of pollutants regulated by the United States Environmental Protection Agency (U.S. EPA).[17]
DBP was added to the California Proposition 65 (1986) list of suspected teratogens in November 2006. It is a suspected endocrine disruptor.[10] It was used in many consumer products, e.g., nail polish, but such usages has declined since around 2006. It was banned in children's toys, in concentrations of 1000 ppm or greater, under section 108 of the Consumer Product Safety Improvement Act of 2008 (CPSIA).
Safety
Phthalates are noncorrosive with low acute toxicity.[1]
See also
References
External links
- Шаблон:ICSC
- Dibutyl Phthalate and Cosmetics
- Hazardous substance fact sheet
- Occupational safety and health guideline for dibutyl phthalate
- CDC - NIOSH Pocket Guide to Chemical Hazards
Шаблон:HealthIssuesOfPlastics Шаблон:Authority control
- ↑ 1,0 1,1 1,2 1,3 Peter M. Lorz, Friedrich K. Towae, Walter Enke, Rudolf Jäckh, Naresh Bhargava, Wolfgang Hillesheim "Phthalic Acid and Derivatives" in Ullmann's Encyclopedia of Industrial Chemistry, 2007, Wiley-VCH, Weinheim. Шаблон:Doi
- ↑ 2,0 2,1 Шаблон:Cite book
- ↑ Шаблон:Cite journal
- ↑ Шаблон:Cite journal
- ↑ Шаблон:Cite thesis
- ↑ Шаблон:Cite journal
- ↑ Шаблон:Cite journal
- ↑ Шаблон:Cite journal
- ↑ Шаблон:Cite journal
- ↑ 10,0 10,1 Шаблон:Cite journal
- ↑ EU Council Directive 76/768/EEC of 27 July 1976 on the approximation of the laws of the Member States relating to cosmetic products
- ↑ Ban of phthalates in childcare articles and toys, press release IP/99/829, 10 November 1999
- ↑ Шаблон:Cite web
- ↑ Шаблон:Cite web
- ↑ Directive 2011/65/EU of the European Parliament and of the Council of 8 June 2011 on the restriction of the use of certain hazardous substances in electrical and electronic equipment Text with EEA relevance
- ↑ Commission Delegated Directive (EU) 2015/863 of 31 March 2015 amending Annex II to Directive 2011/65/EU of the European Parliament and of the Council as regards the list of restricted substances
- ↑ Шаблон:Cite journal
